I was driving down the highway and my ac vents started blowing hot air, then my car started to putt like it wanted to stop, then thick smoke started coming out my AC vents filling my car to the point I could not see. I pulled over and my entire car was full of smoke and I began to choke as I put the car in park and crawled out my smoking car. Bystanders pulled over to help me and my car was smoking from the engine and back of car. The police and fire department were called and I was take to a local hospital by ambulance for smoke inhalation.

When starting the car, the park light flashes on the dashboard and the electronic parking brake will not disengage. The brake will also not disengage if you switch into gear and try to start driving like it would if the electronics were working properly. There is a start error message displayed on the dashboard as well when the car is started: I had to turn the car off and on dozens of times before it resolved. A google search revealed this is happening to a lot of owners of the ‘23 rogues. One person needed a chip replaced. Others said the only way they could get the car to move was turning the car on and off, sometimes taking hours. I was stranded without being able to drive away.

I turn on the car with the remote and it doesn't work; then when I try to start the car, it won't start, it gives an error and won't start; it all happens because of using the remote start; they updated the software because they didn't want to replace the engine due to a recall of defective bearings, and now they've made the starting problem worse, claiming it's an injector issue; they scanned it, reset it, and it's working again; so what injector problems does the software say it has??? It only happens when I plug a device into the USB port or when I start the car remotely; I'm frustrated because it's my work vehicle.

I am filing this formal complaint to request immediate NHTSA intervention regarding Nissan North America’s bad-faith denial of critical safety recall repairs on my 2023 Nissan Rogue. Both Nissan Consumer Affairs and my local Nissan dealership service department are actively misdiagnosing a severe, well-documented engine defect as a "secondary issue" to avoid their legal obligations under NHTSA Recall Campaigns 26V-080 and 26V-081. By forcing me to drive a vehicle that exhibits violent engine shaking and severe, abnormal mechanical noise, Nissan is placing my safety and the safety of the motoring public at immediate risk. They are insisting that I continue operating a compromised vehicle until a catastrophic, total engine failure occurs on the highway. Detailed Timeline of Events and Defect Manifestation June 2025 (Vehicle Under Factory Warranty): The vehicle began exhibiting abnormal, excessively loud engine noises. I presented the vehicle to the authorized Nissan dealership for diagnosis. The service department dismissed the issue, claiming they "could not replicate" the noise, and released the vehicle back to me without repair. I captured digital video and audio recordings of the defect at this time to preserve empirical evidence. February 2026: NHTSA and Nissan announced recalls 26V-080 and 26V-081 specifically targeting the 1.5L and 2.0L VC-Turbo engines for main bearing failure, which causes violent engine shaking, severe noise, knocking, and sudden loss of motive power. [XXX]: As the engine noises worsened and progressed into violent engine shaking, I brought the Rogue back to the dealership service department. They admitted the vehicle was shaking excessively but claimed it was a "secondary issue" caused by a failing Exhaust Gas Recirculation (EGR) valve. Manufactured/dealership explicitly stated that because they did not yet find metal shavings in the oil pan, they would not authorize the recall remedy. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I woke about 6am this morning and when i looked outside i noticed my vehicle was turned on Independently and there were several warning lights and the gear shift was not lite up and the Stop/Start System was on as well as the warning malfunction see owners manual i turned the vehicle off turned it back on and cleaned the sensors still the same issue I called Geico this morning had the vehicle towed to the dealership and they informed that the brake switch it faulty and needed to be replaced the brake fluid needed to flushed and the rear brakes needed to be placed.